Concrete Contractors in Caledonia, WI

Caledonia is big, and concrete contractors here cover everything from lakeside homes to rural lots with long driveways. The village spans about 45 square miles of land and had 25,361 residents in 2020. Its 10,667 housing units are spread out, with only 3.8 percent vacant. Caledonia became a village after a 2005 referendum, having been a town until then.

Different corners of the village

Caledonia includes several named communities:

• Franksville, a residential community and former census-designated place
• Husher, a residential neighborhood
• Tabor, a lakeside community

Between them are subdivisions and rural lots. The concrete work varies with the setting. In subdivisions, we replace driveways and pour patios. On rural lots, we pour slabs for pole barns and detached garages and replace long stretches of driveway near the house.

Long drives and outbuilding slabs

A rural driveway takes more abuse than a suburban one. Delivery trucks, trailers and farm equipment can all crack a slab that was poured too thin. For a Caledonia driveway or outbuilding slab, we: 1. Dig out topsoil and soft material down to firm ground 2. Place and compact stone in layers 3. Choose thickness and reinforcement for the heaviest vehicle that will use it 4. Pour air-entrained concrete and cut joints at the right spacing 5. Cure it properly before traffic

For a garage or barn slab, we thicken the edges where the walls bear and coordinate anchor bolts with your builder.

Get a Free Estimate

Near the lake in Tabor

Lakeside lots face wind and lake-effect weather off Lake Michigan. Fresh concrete dries fast in wind, and a surface that dries too quickly can crack or scale. We plan pour days with the forecast in mind and protect the slab while it cures. For patios here, owners often want stamped concrete, which we seal to help it stand up to weather and salt.

Garage slabs that last

A garage floor works differently from a driveway. It carries cars, holds water dripping off them in winter, and often supports walls at the edges. A good garage slab in Caledonia gets:

• A compacted stone base under the whole floor
• Thickened edges where the walls bear
• Reinforcement sized for vehicles
• A slight slope toward the door so meltwater runs out instead of pooling
• A vapor barrier where moisture from below is a concern
• Isolation joints where the slab meets the apron and any existing foundation

We also pay attention to the apron, the short slab between the garage door and the driveway. Aprons take a lot of stress and often settle first, especially on newer lots where backfill near the foundation is still compacting. When we pour a new garage or replace an apron, we tie the base and joints together so the floor, apron and driveway work as one system.

Tell us about access

On larger Caledonia properties, the pour location may be far from the road. Let us know about soft ground, septic fields, buried lines, overhead wires or narrow gates between the street and the work area. We plan truck routes to avoid driving over a septic system or soft lawn, and we use a pump or other placement method when a truck cannot get close.

Caledonia's housing is close to fully occupied, with a homeowner vacancy rate of 1.1 percent in 2020. Homes that stay occupied year after year are worth a slab built to last decades rather than a quick patch, and that is how we plan the work.

Steps, walks and repairs

We also pour front steps, walks and side paths, and repair or replace cracked and sunken sections anywhere in the village. Caledonia sits at about 659 feet. On flat ground, we set slopes carefully so water runs off. We check whether the Village of Caledonia requires a permit for your work before scheduling.